Abstract
One kind of heat treatment machine for powder material was designed to use the metal screw impellor inside the sterilization chamber as the heating component connected to high frequency electricity. As strong magnetic field was generated during the process, the accuracy of temperature at critical control point (CCP) of the material measured by platinum resistor would be influenced, and this entailed the electromagnetic shielding (EM shielding). Based on both theoretical analysis and virtual simulation, our research was intended to design the shielding device. The relationships between the shielding effectiveness and the relative permeability, relative conductivity and thickness of different materials were analyzed. After narrowed down to several kinds of materials with various thickness, the shielding effectiveness of these materials was calculated by virtual simulation. It was found that Mn-Zn ferrite would be the proper shielding material for platinum resistor and the effectiveness of a 3 mm thick Mn-Zn ferrite cylinder shield could be higher than 40 dB. The shielding effect of this device prototype was proved to be acceptable in this study.
Publication Date
3-28-2017
First Page
71
Last Page
74,79
DOI
10.13652/j.issn.1003-5788.2017.03.016
Recommended Citation
Yi, TAO; Jianrong, CAI; Shiqing, ZHANG; Li, SUN; and Xin, LI
(2017)
"Study on electromagnetic shielding of temperature sensor which measures the temperature of powder food in high frequency electrothermal sterilization equipment,"
Food and Machinery: Vol. 33:
Iss.
3, Article 15.
DOI: 10.13652/j.issn.1003-5788.2017.03.016
Available at:
https://www.ifoodmm.cn/journal/vol33/iss3/15
References
[1] 蔡健荣, 杨军义, 庄晓波, 等. 一种基于趋肤效应的香辛料热杀菌技术装备[J]. 中国农业科技导报, 2015, 17(5): 63-67.
[2] 杨武, 王小华, 荣命哲, 等. 基于红外测温技术的高压电力设备温度在线监测传感器的研究[J]. 中国电机工程学报, 2002, 22(9): 113-117.
[3] ZHANG Xun, JIN Dong-ming, LIU Li-tian. Review of semiconductor temperature sensors development[J]. Transducer & Microsystems Technologies, 2006, 25(3): 1-3.
[4] 刘华. 铂热电阻在线检测方法的研究[D]. 西安: 西安理工大学, 2005: 1.
[5] 张传民, 甄国涌, 齐蕾, 等. 铂电阻线性化和抗干扰测温模块的研究[J]. 自动化与仪表, 2014, 29(10): 72-76.
[6] 丁世敬, 赵跃智, 葛德彪. 电磁屏蔽材料研究进展[J]. 材料导报, 2008, 22(4): 30-33.
[7] GUAN Hong-tao, LIU Shun-hua, DUAN Yu-ping, et al. Cement based electromagnetic shielding and absorbing building materials[J]. Cement & Concrete Composites, 2006, 28(5): 468-474.
[8] WILSON P F, MA M T. Techniques for measuring the electromagnetic shielding effectiveness of materials. I. Far-field source simulation[J]. IEEE Transactions on Electromagnetic Compatibility, 1988, 30(3): 239-250.
[9] DU Ya-ping, XIA Neng-hong, CHEN Ming-li. Joint Modeling for Conductive Plates in Low-Frequency Magnetic Shielding[J]. IEEE Transactions on Magnetics, 2013, 49(5): 2 005-2 008.
[10] LEE P C, KIM B R, SUN K J, et al. Electromagnetic interference shielding effectiveness of polypropylene/conducting fiber composites[J]. Aip Conference Proceedings, 2016, 1 713(1): 922-925.
[11] YANG Shu-ying, LOZANO K, LOMELI A, et al. Electromagnetic interference shielding effectiveness of carbon nanofiber/LCP composites[J]. Composites Part A Applied Science & Manufacturing, 2005, 36(5): 691-697.
[12] FUGETSU B, SANO E, SUNADA M, et al. Electrical conductivity and electromagnetic interference shielding efficiency of carbon nanotube/cellulose composite paper[J]. Carbon, 2008, 46(9): 1 256-1 258.
[13] MAITI S, SHRIVASTAVA N K, SUIN S, et al. Polystyrene/MWCNT/Graphite Nanoplate Nanocomposites: Efficient Electromagnetic Interference Shielding Material through Graphite Nanoplate-MWCNT-Graphite Nanoplate Networking[J]. Acs Applied Materials & Interfaces, 2013, 5(11): 4 712-4 724.
[14] ZHAO Yu-tong, WU Bian, ZHANG Yu, et al. Transparent electromagnetic shielding enclosure with CVD graphene[J]. Applied Physics Letters, 2016, 109(10): 103 507.
[15] WANG Xiao-wei, REN Shi-yan, YANG Hua-yun, et al. FEM Analysis of Magnetic Shielding Effectiveness[J]. Acta Metrologica Sinica, 2006, 27(4): 376-379.
[16] 黎文航, 朱志愿, 芦笙, 等. 基于LabVIEW的高精度铂电阻测温系统开发[J]. 微计算机信息, 2009, 25(31): 50-51.
[17] 朱杰, 徐香菊, 钱爰颖, 等. 基于铂电阻的高精度温度采集系统校准研究[J]. 化工自动化及仪表, 2012, 39(4): 525-527.
[18] 王婵媛, 王希晰, 曹茂盛. 轻质石墨烯基电磁屏蔽材料的研究进展[J]. 材料工程, 2016, 44(10): 109-118.
[19] 切洛齐. 电磁屏蔽原理与应用[M]. 北京: 机械工业出版社, 2010: 65-68.
[20] WESTON D. Electromagnetic Compatibility: Principles and Applications[M]. 2th ed. Boca Raton: CRC Press, 2001: 61-62.
[21] 李安金, 赵仁涛. 低频磁场屏蔽问题简述[J]. 科技信息, 2013(3): 211-212.
[22] 杨士元. 电磁屏蔽理论与实践[M]. 北京: 国防工业出版社, 2006: 134-135.