Abstract
[Objective] This study aimed to optimize the process of deep eutectic solvent extraction of flavonoids from exocarpium Citri grandis and to evaluate its antioxidant activity. [Methods] The type of deep eutectic solvent system, the water content of deep eutectic solvent, material-to-liquid ratio, extraction temperature, and extraction time were selected as experimental variables, and the yield of flavonoids was used as response variables to conduct single factor experiment. Then the single factors with significant differences were screened to optimize the process of deep eutectic solvent extraction of exocarpium C. grandis flavonoids by response surface methods. Finally, the scavenging ability of exocarpium C. grandis flavonoid extract on DPPH radicals, ABTS radicals, and hydroxyl radicals was explored to analyze the antioxidant activity. [Results] The highest yield of exocarpium C. grandis flavonoid was obtained by the choline chloride-glycol system. The yield of flavonoids was significantly impacted by the deep eutectic solvent's water content, the material-to-liquid ratio, and the extraction temperature. The response surface method was used to determine the ideal flavonoid extraction procedure, which included the deep eutectic solvent's water content of 43%, the material-to-liquid ratio of 1∶21 (g/mL), and the extraction temperature of 60 ℃. The yield of exocarpium C. grandis flavonoids was (19.31±0.47) mg/g. The results of antioxidant activity showed that the concentration for 50% of maximal effect values of DPPH radical, ABTS radical, and hydroxyl radical scavenging were (117.61±1.71), (36.91±0.46), (387.52±1.85) μg/mL. [Conclusion] The extraction of exocarpium C. grandis flavonoids using deep eutectic solvent resulted in significantly higher yields compared with conventional water and ethanol method. These flavonoid extracts had potential as a source of natural antioxidants.
Publication Date
9-11-2024
First Page
192
Last Page
199
DOI
10.13652/j.spjx.1003.5788.2023.80919
Recommended Citation
Yongyi, LIANG; Dongyue, XIAO; Hong, WANG; Yizhu, LIANG; and Xiaofang, ZENG
(2024)
"Optimization of deep eutectic solvent extraction process and antioxidant activities of flavonoids from exocarpium Citri grandis,"
Food and Machinery: Vol. 40:
Iss.
7, Article 28.
DOI: 10.13652/j.spjx.1003.5788.2023.80919
Available at:
https://www.ifoodmm.cn/journal/vol40/iss7/28
References
[1] ZENG X, SU W, ZHENG Y, et al. UFLC-Q-TOF-MS/MS-based screening and identification of flavonoids and derived metabolites in human urine after oral administration of exocarpium Citri grandis extract[J]. Molecules, 2018, 23（4）: 895.
[2] WU X, WU J, HUANG B, et al. The effects of exocarpium Citri grandis on the volatile components of green teabased on HS-SPME-GC-MS[J]. IOP Conference Series: Earth and Environmental Science, 2021, 769（2）: 22041.
[3] FENG F. Research progress on chemical composition and pharmacological action of exocarpium Citri grandis[J]. Highlights in Science, Engineering and Technology, 2022（2）: 222-229.
[4] 王艳慧. 化橘红的研究进展[J]. 世界科学技术—中医药现代化, 2017, 19（6）: 1 076-1 082.
WANG Y H. Research progress of Citri grandis exocarpium[J]. World Science and Technology/Modernization of Traditional Chinese Medicine and Materia Medica, 2017, 19（6）: 1 076-1 082.
[5] LIAO S, SONG F, FENG W, et al. Rhoifolin ameliorates titanium particle-stimulated osteolysis and attenuates osteoclastogenesis via RANKL-induced NF-kappaB and MAPK pathways[J]. J Cell Physiol, 2019, 234（10）: 17 600-17 611.
[6] PENG Y, HU M, LU Q, et al. Flavonoids derived from exocarpium Citri grandis inhibit LPS-induced inflammatory response via suppressing MAPK and NF-κB signalling pathways[J]. Food and Agricultural Immunology, 2019, 30（1）: 564-580.
[7] 王雯. 化橘红总黄酮提取纯化工艺及其功效研究[D]. 南昌: 江西农业大学, 2013: 49.
WANG W. Studies on extraction, purification and efficacy of total flavonoids from exocarpium Citri grandis[D]. Nanchang: Jiangxi Agricultural University, 2013: 49.
[8] HE Y J, ZHU M, ZHOU Y, et al. Comparative investigation of phytochemicals among ten citrus herbs by ultra highperformance liquid chromatography coupled with electrospray ionization quadrupole time-of-flight mass spectrometry and evaluation of their antioxidant properties[J]. J Sep Sci, 2020, 43（16）: 3 349-3 358.
[9] ZHU Z, WU H, SU W, et al. Effects of total flavonoids from exocarpium Citri grandis on air pollution particle-induced pulmonary inflammation and oxidative stress in mice[J]. J Food Sci, 2019, 84（12）: 3 843-3 849.
[10] 段志芳, 方丹, 李亚梅, 等. 化橘红中清除自由基有效成分的研究[J]. 中国食品添加剂, 2021, 32（1）: 13-17.
DUAN Z F, FANG D, LI Y M, et al. Study on the DPPH radical-scavenging active components in exocarpium Citri grandis （ECG） [J]. China Food Additives, 2021, 32（1）: 13-17.
[11] 罗蓉, 蔡旭, 薛宏坤, 等. 响应面法优化超声辅助低共熔溶剂提取山楂总黄酮工艺[J]. 食品工业科技, 2022, 43（22）: 229-237.
LUO R, CAI X, XUE H K, et al. Optimization of ultrasonic-assisted deep eutectic solvent extraction of flavonoids from Crataegus pinnatifida using response surface methodology[J]. Science and Technology of Food Industry, 2022, 43（22）: 229-237.
[12] 于秋菊, 耿凤英, 张磊磊. 微波辅助低共熔溶剂提取覆盆子总黄酮的工艺优化及活性研究[J]. 中国食品添加剂, 2023, 34（2）: 43-51.
YU Q J, GENG F Y, ZHANG L L, et al. Optimization of microwave assisted extraction of flavonoids from raspberry with deep eutectic solvents and its activity[J]. China Food Additives, 2023, 34（2）: 43-51.
[13] LIU X M, LIU Y, SHAN C H, et al. Effects of five extraction methods on total content, composition, and stability of flavonoids in jujube[J]. Food Chem: X, 2022, 14: 100287.
[14] 宋晓凡, 李岩, 张一茹, 等. 地皮菜总黄酮提取工艺优化及抗氧化活性评价[J]. 食品科技, 2021, 46（12）: 210-216.
SONG X F, LI Y, ZHANG Y R, et al. Optimization of extraction and antioxidant activity evaluation of total flavonoids from nostoc commune[J]. Food Science and Technology, 2021, 46（12）: 210-216.
[15] 徐洪宇, 蒯宜蕴, 詹壮壮, 等. 果皮中酚类物质含量、抗氧化活性及在体外消化过程中成分的变化[J]. 食品科学, 2019, 40（15）: 23-30.
XU H Y, KUAI Y Y, ZHAN Z Z, et al. Phenolic contents and antioxidant activity of fruit peels and changes in phenolic composition during in vitro simulated digestion[J]. Food Science, 2019, 40（15）: 23-30.
[16] 陈建福, 彭敏. 芦柑叶总黄酮的提取工艺优化及其抗氧化活性研究[J]. 食品研究与开发, 2021, 42（4）: 117-122.
CHEN J F, PENG M. Optimization of extraction technology of total flavonoids from ponkan leaves and its antioxidant activity[J]. Food Research and Development, 2021, 42（4）: 117-122.
[17] LAMEI N, EZODDIN M, ABDI K. Air assisted emulsification liquid-liquid microextraction based on deep eutectic solvent for preconcentration of methadone in water and biological samples[J]. Talanta, 2017, 165: 176-181.
[18] VILKOV M, POTKA-WASYLKA J, ANDRUCH V. The role of water in deep eutectic solvent-base extraction[J]. Journal of Molecular Liquids, 2020, 304: 112747.
[19] 王育红, 张晓宇, 钱志伟. 响应面优化低共熔溶剂提取黄精黄酮工艺及其生物活性研究[J]. 中国食品添加剂, 2023, 34（4）: 116-123.
WANG Y H, ZHANG X Y, QIAN Z W. Optimization of extraction of flavonoid from Polygonatum kingianum with deep eutectic solvent by response surface method and its bioactivity[J]. China Food Additives, 2023, 34（4）: 116-123.
[20] 余捷, 李亚娜, 夏瑾瑾, 等. 复合酶辅助提取荷叶多糖工艺优化及其体外抗氧化活性[J]. 食品研究与开发, 2023, 44（24）: 115-121.
YU J, LI Y N, XIA J J, et al. Optimization of complex enzyme-assisted extraction of polysaccharide from lotus leaves and its antioxidant activity[J]. Food Research and Development, 2023, 44（24）: 115-121.
[21] 刘敏卓, 张小月, 张灵芝, 等. 竹茹总黄酮超声波处理与纤维素酶协同提取工艺优化及其体外抗氧化活性分析[J]. 食品工业科技, 2023, 44（20）: 221-229.
LIU M Z, ZHANG X Y, ZHANG L Z, et al. Optimization of ultrasonic wave and cellulase synergistic extraction technology of total flavonoids from Bambusae caulis in taeniam and their antioxidant capacity in vitro[J]. Science and Technology of Food Industry, 2023, 44（20）: 221-229.
[22] 苏慧慧, 许菲, 吴定坤, 等. 响应面优化三叶木通总黄酮的提取工艺及其抗氧化活性[J]. 北方园艺, 2022（21）: 100-105.
SU H H, XU F, WU D K, et al. Optimization of extraction conditions of flavonoids from Akebia trifoliata by response surface methodology and its antioxidant activity[J]. Northern Horticulture, 2022（21）: 100-105.
[23] ZHANG X, SU J, CHU X, et al. A green method of extracting and recovering flavonoids from Acanthopanax senticosus using deep eutectic solvents[J]. Molecules （Basel, Switzerland）, 2022, 27（3）: 923.
[24] ZUO J, MA P, GENG S, et al. Optimization of the extraction process of flavonoids from Trollius ledebouri with natural deep eutectic solvents[J]. Journal of Separation Science, 2022, 45（3）: 717-727.
[25] 陈亦璐, 徐梦兰, 邓健善, 等. 化橘红黄酮的高压脉冲电场提取及抗氧化活性检测[J]. 湖南农业大学学报（自然科学版）, 2021, 47（3）: 305-311.
CHEN Y L, XU M L, DENG J S, et al. Pulsed electric field extraction of flavonoids from exocarpium Citri grandis and its antioxidant activity detection[J]. Journal of Hunan Agricultural University （Natural Sciences）, 2021, 47（3）: 305-311.